INSPECTION REPORT Health Protection RWOG-B87V5H

PREMISES NAME Healthy Soy Foods		Tel: (604) 434-8868 Fax: (604) 434-8868
PREMISES ADDRESS 6360 Arbroath St Burnaby, BC V5E 1C4		INSPECTION DATE January 7, 2019	TIME SPENT 2 hours
OPERATOR (Person in Charge) Rui Feng Wang		NEXT INSPECTION DATE January 11, 2019
INSPECTION TYPE Routine
ACTION TAKEN		FOOD SAFETY & SANITATION
ADMINISTRATIVE Information Provided	ENFORCEMENT Require Corrections	Comply In Use Food Safety Training [s. 10] Food Safety Plan [s. 23] Sanitation Plan [s. 24]
HAZARD RATING FOR YOUR FACILITY: High (≥30) Total Score = 41

Critical Hazards: Total Number: 1

201 - Food contaminated or unfit for human consumption [s. 13] Observation (CORRECTED DURING INSPECTION): Two bags of soy beans stored in storage container portion of premises is mouldy. Corrective Action(s): - Soy bean discarded at the time of inspection - All foods must be stored in the premises itself as the storage container is not adequate for food storage. Violation Score: 15

Non-Critical Hazards: Total Number: 4

209 - Food not protected from contamination [s. 12(a)] Observation: 1) Rain water leaking into storage container has soaked boxes containing food storage containers. 2) Water pooling on the floor throughout production area Corrective Action(s): 1) Discard all food packaging that has been contaminated by rain water. Bring packaging into the warehouse and store where there are no leaks. 2) Water from steam tables cannot be allowed to directly drain onto the floor. Pooling water may be contamined by workers, and may splash up onto food. Repair the source of the leak. Violation Score: 9 304 - Premises not free of pests [s. 26(a)] Observation: Significant amount of droppings along the display doors of the walk-in cooler. Corrective Action(s): - Clean and sanitize areas noted with a 1:10 bleach solution (1 cup bleach in 10 cups water) - Ensure that all points of entry are sealed - Store foods in pest proof containers - Follow all recommendations from the pest control company Violation Score: 9 306 - Food premises not maintained in a sanitary condition [s. 17(1)] Observation: Equipment underneath the vent hood in production area covered in grease. Corrective Action(s): Clean and sanitize areas noted. Violation Score: 3 311 - Premises not maintained as per approved plans [s. 6(1)(b)] Observation: Storage containers used as store rooms leak. Rain water noted all along the floors and on shelves. Corrective Action(s): Do not store any food products or food packaging in this trailer. Violation Score: 5

Follow Up to "Critical" Violations Noted on Previous Inspections (if applicable): No corrections entered

Comments

- not in full operation at the time of inspection - handwashing station stocked with soap, paper towels and hot and cold running water - hairnets, uniforms and boots worn by staff - sanitizer measured 200ppm quats in the spray bottles - two compartment sink available for warewashing (not set up at the time of inspection); bleach available for sanitizing - walk-in cooler: 4C - chest freezer: -20C - recommend defrosting freezer so that the lid is able to fully close Note: Storage trailer section to be demolished and rebuilt. Plans have already been drawn and will be submitted to the City of Burnaby shortly. Do not begin renovating until health approval has been given.