INSPECTION REPORT Health Protection RWOG-BEDTFG

PREMISES NAME Healthy Soy Foods		Tel: (604) 434-8868 Fax: (604) 434-8868
PREMISES ADDRESS 6360 Arbroath St Burnaby, BC V5E 1C4		INSPECTION DATE July 24, 2019	TIME SPENT 1 hour
OPERATOR (Person in Charge) Rui Feng Wang		NEXT INSPECTION DATE 3 Months
INSPECTION TYPE Follow-Up
ACTION TAKEN		FOOD SAFETY & SANITATION
ADMINISTRATIVE Information Provided	ENFORCEMENT Require Corrections	Comply In Use Food Safety Training [s. 10] Food Safety Plan [s. 23] Sanitation Plan [s. 24]
HAZARD RATING FOR YOUR FACILITY: Low (≤15) Total Score = 17

Critical Hazards: Total Number: 1

302 - Equipment/utensils/food contact surfaces not properly washed and sanitized [s. 17(2)] Observation (CORRECTED DURING INSPECTION): Bottles of sanitizer measured 50-100ppm quats. Corrective Action(s): All bottles emptied and refilled with a 200ppm chlorine solution at the time of inspection. Violation Score: 5

Non-Critical Hazards: Total Number: 2

209 - Food not protected from contamination [s. 12(a)] Observation: Mould observed on unused packaging. Owner stated that it was an old design and was not being used. Corrective Action(s): Discard packaging. Violation Score: 9 306 - Food premises not maintained in a sanitary condition [s. 17(1)] Observation: Mould build up throughout building. Corrective Action(s): Clean and sanitize areas where mould is found. Violation Score: 3

Follow Up to "Critical" Violations Noted on Previous Inspections (if applicable): No corrections entered

Comments

- handwashing station stocked with soap, paper towels and hot and cold running water - hot water available at warewashing sink - two compartment sink available for warewashing (not set up at the time of inspection); bleach available for sanitizing - walk-in cooler: 3C - chest freezer: -19C - Facility recently had boiler repaired and has been voluntarily shut down since July 15, 2019 and has began operations again July 23, 2019 - Ensure that your health inspector is informed if there are any major issues, such as the boiler requiring repair, occur - All old stock to be discarded (soups, sauces, any expired foods) - New stock being produced at the time of inspection - Rodent issue seems to have improved - no build up of droppings in the coolers or in corners; continue monitoring - Floor plan for new building discussed; plans have been sent to the City of Burnaby for approval, and will subsequently be submitted to the health department